| Sprayed Content | ||
| Use | Content | Remarks |
Thermal and acoustic insulation, and fire protection products. |
Sprayed coatings contain up to 85% asbestos. A mixture of asbestos types was used until 1974. Chrysotile was also used as a coating on top of other sprayed asbestos. | * Applications ceased in 1974 * Extremely friable – high potential for fibre release. * Repair and removal must only be carried out by a licensed contractor. * Example of use: sprayed on structural steelwork. |
| Lagging | ||
| Use | Content | Remarks |
| Thermal insulation of pipes, boilers, pressure vessels, pre-formed pipe sections, slabs, tape, rope, corrugated paper, quilts, felts and blankets. | Asbestos content varies: 100% in asbestos blankets, felts, etc. 15% in magnesium carbonate insulation with an asbestos surface coat, 6-8% in calcium silicate slabs. All types of asbestos used. | * Asbestos lagging is unlikely to be found in
buildings constructed after 1975. * Potential for fibre release unless sealed. * Potential increases if material is disturbed or damaged. * Removal must be carried out by a licensed contractor. * Widely used for pipe and boiler lagging, and insulation between floors. |
| Insulating Boards | ||
| Use | Content | Remarks |
| Fire protection, thermal and acoustic insulation, general building work. | Common trade name e.g. ‘Asbestolux’. Insulating boards contain 16-40% amosite, or mixture of amosite and chrysotile. Crocidolite was used for some boards up to 1965. | * Widely used up to
mid-1970s. * Work on Insulating board can give rise to very high levels of fibre. * Likely to cause dust if very friable, broke, abraded, drilled or sawed. * Removal should be undertaken by a licensed contractor. * Widely used in all types of industrial, commercial, public and private building. * Used widely in ducts, as fire-breaks, infill panels, partitions, ceiling tiles, roof underlays, wall linings, bath panels, etc. |
| Ropes and Yarns | ||
| Use | Content | Remarks |
| Lagging, jointing and packing materials, heat/fire resistant gaskets and seals, caulking in brickwork, boiler and flue sealing. | Asbestos content approx. 100%. All types of asbestos have been used up to 1970. Since then only Chrysotile has been used. | * Fibre may be released
when large quantities of unbonded material are stored
or handled. * Caulking, etc. in situ is not likely to release fibres. * Removal should be undertaken by a licensed contractor. |
| Cloth | ||
| Use | Content | Remarks |
| Jointing and packing, gaskets, thermal insulation and lagging, including fire blankets, mattresses and protective curtains, gloves, aprons, overalls, etc. | Asbestos content approx. 100%. All types of asbestos have been used, mostly Chrysotile. | * Fibres may be released
if material is abraded or frayed. * Equipment using asbestos cloth is found in foundries, laboratories and kitchens. |
| Millboard, Paper and Paper Products | ||
| Use | Content | Remarks |
| General heat insulation and fire protection, electrical and heat insulation, roofing felt, damp-proof courses, steel composite wall cladding and roofing, vinyl flooring, facing to combustible boards, flame-resistant laminate and corrugated pipe insulation. | Asbestos content approx. 100%. All three types have been used; Chrysotile only after 1965. | * Uncoated products
not highly bonded and liable to release fires when
subject to abrasion or wear. Can be a hazard when
handled * Removal should be undertaken by a licensed contractor. |
| Asbestos Cement Products | ||
| Use | Content | Remarks |
| Profiled sheets, roofing, wall cladding and weather boarding. Semi -compressed flat sheet and partition board. Fully compressed flat sheet and partition board. Tiles and slates. Preformed moulded products, cisterns and tanks, drains, sewer pipes, rainwater goods, flue pipes, fencing, roofing components, cable troughs and conduits, ventilators, ducts, window boxes, etc. | Asbestos content 10-15% bound in a matrix of Portland cement or calcium silicate. All three types have been used. Crocidolite between 1950 and 1969, and Amosite from 1945 to at least 1976, but mainly Chrysotile. | * Widely used in many
types of buildings * Asbestos fibres are firmly bound and only released if the material is mechanically damaged or deteriorates with age. * Cleaning weathered cement has the potential to release fibres. * Care should be taken to prevent accidents from falling through fragile asbestos cement roofs. * Can be pained to seal, prevent warping and reduce surface deterioration. |
| Asbestos Bitumen Products | ||
| Use | Content | Remarks |
| Roofing felts, damp-proof courses, semi-rigid roofing, gutter linings and flashings and coatings on metals. | Chrysotile fibre or asbestos paper (approx. 100% asbestos) in bitumen. | * Fibre release unlikely
during normal use. * Felt and damp-proof courses can become brittle and break up with age. * These products must not be burnt after removal. Asbestos may be released from coatings during fire. |
| Flooring Materials | ||
| Use | Content | Remarks |
| Floor tiles and backing for PVC flooring. | Termoplastic floor tiles – up to 25% asbestos. PVC and unbacked PVC flooring – normally less than 10% Chrysotile. Asbestos-paper backed PVC flooring – paper backing approx. 100% Chrysotile. | * Fibre release unlikely
under normal conditions of use but is possible when
material is cut, or flooring particularly when paper
backing is removed. * When removal is necessary, flooring should be lifted carefully, and any dust dampened and collected. * Waste material must not be removed with a power sander. |
| Textured Coatings and Paints | ||
| Use | Content | Remarks |
| Coatings on walls and ceilings. | Asbestos content 3-5% Chrysotile | * Potential for fibre
release when dry mixes are prepared or when old coating
is rubbed down. * Materials must not be power sanded or scraped off dry * Materials must be pre-wetted by soaking with water. * Other may require treatment with paint stripper before removal. * Wet material must be placed in plastic sacks (double-bagged). * Supply and application has been prohibited since 1988, but still widely in place, e.g. Artex. |
| Mastics, Sealants, Putties and Adhesives | ||
| Use | Content | Remarks |
| Asbestos may be included in these products. | Asbestos content 0.5% - 2% | * Potential for fibre
release on sanding of hardened material. * Sanding with power tools should be avoided. * Appropriate precautions should be taken when working with these materials. |
| Reinforced Plastics | ||
| Use | Content | Remarks |
| PVC panels and cladding, and reinforcement for domestic goods. | Variable, mostly Chrysotile | Unlikely to release fibres during use but cutting with power tools should be avoided. |
| Wall Plugging compound | ||
| Use | Content | Remarks |
| Wall fixings. | Asbestos content greater than 90%. Products are made up from loose asbestos and cotton fibre with plaster dust.
|
n/a |
| Domestic Appliances | |
| Use | Content |
Formerly used in a variety of appliances for heat insulation: Hairdryers, fan and radiant heaters, toasters, washing machines, tumble dryers, spin dryers, dish washers, refrigerators and freezers. |
Variable asbestos content approaching 100% in millboard, asbestos paper and compressed asbestos panels. |
| Cookers | Paper, element formers, brake pads, compressed fibre gaskets and seals, rubberised or other polymer gaskets and seals |
| Simmering mats | Insulating board, fire cement, compressed fibre seals, rubberised or other polymer seals. |
| Oven gloves, fire blankets | Millboard |
| Catalytic gas heaters | Paper, millboard and asbestos cement |
| Gas warm-air heaters | Textiles |
| Boilers, pipework | Compressed asbestos fibre panels, sometimes covered by a wire or glass fibre mesh. |
| Electric warm-air and storage heaters | Aluminium backed paper, cloth and insulating board. Asbestos / plaster with or without a surface fibre layer. |
| Radiators | ‘Caposil’ insulating blocks, insulating board, paper , string compressed fibre washers, rubberised or other polymer-branded washers, String, washers. |
“MDHS
Methods for the Determination of
Hazardous Substances”...
“3D
House Plan of Typical Locations Containing
Asbestos Materials”...
“Asbestos
Guidance for
Safety Representative”...
Take advantage of our expertise
and our
FREE NO OBLIGATION
Asbestos Survey Quotation.
Get in touch today - Call Head Office
01926 434444
or email Midland Asbestos Surveys Services
